Categories: Agribusiness

Cross-flow turbines free farm from Eskom

In 1974, the Brak River, a tributary of the Great Fish River near Cradock was transformed from a tiny stream…

“My late father, Keith, was keen on using natural energy wherever possible, making solar panels and trying a little bit of this and a little bit of that,” says Norman Collett. But there wasn’t much Keith could do with the water of the Brak River, which flowed past the family farm. It was used for flood irrigation, but there was simply too little water to generate energy.

Things changed in 1974 when this tributary of the Great Fish River near Cradock changed from a tiny stream to a fast-flowing river as water from the Orange-Fish Tunnel was released into it. By the early 1980s, Keith had erected two turbines which provided one-phase household electricity to Grassridge Farm, thereby ensuring it was no longer dependent on Eskom. Keith’s turbines eventually generated a total of 12kW.

Then, about five years ago, André Muller, Norman’s son-in-law, suggested introducing centre pivots to produce extra feed for the Dohne Merinos and Brangus/Bonsmara cattle on the 4 500ha farm.

Electricity Costs
There was a problem, though. The cost of getting Eskom to install the necessary line was simply too high. So the family turned to the Brak River once more. Norman told André that since he had gone to university and done “all these clever things”, why didn’t he “sit down and do a pretty sum”, and work out what it would cost to install new turbines.

“André told me that from the figures received from the manufacturers, we could pay off the new turbines in five years,” recalls Norman. Fortunately, because no water was diverted from the Brak River to the turbines, there were no legal implications removing the old and installing the new turbines.

However, because work on the micro-hydropower station could only be done during the three-week dry period when the water affairs department switches off the flow from the gariep dam, the installation of the turbines and the new three-phase electrical system represented a long-term project that would cost R1,8 million.

Norman explains that in 2009 they had to modify the old stone walls and build new sluice gates. In 2010, the old turbines were removed and replaced by two new cross-flow turbines from Vortex Hydro Systems. In 2011, another turbine was installed, and the new power lines were constructed to accommodate three-phase power.

Although Vortex provided assistance, it was still a daunting engineering task for a Karoo livestock farmer, says Norman. “There were nights when I just lay there and thought about how I was going to pick up those machines and put them down there.”
In the end, however, he came up with an ingenious plan. During the construction of the Grassridge Dam in the 1920s, cocopans had been used. The Colletts had acquired one, along with tracks.

This antiquated system proved to be the most cost-effective way of inching 1t turbines down a steep river bank. “That is what it was built for,” says Norman, as we near a centre pivot that was installed only a few months ago. “The biggest thrill for me was when I switched this thing on.”

Reaping the benefits
At the pump house, he shows me the 17kW motor that drives the centre pivot that irrigates teff on old flood-irrigated lands and virgin soil. He’ll be installing another pivot that will be fed by water flowing from a canal at an elevated position. This will create enough natural energy to enable a smaller 4kW motor to drive the centre pivot. Besides the pivot, the Grassridge Farm turbines supply electricity to three staff quarters, the workshop and a number of submersible pumps on the farm. In fact, says Norman, more electricity is currently being produced than can be used on Grassridge Farm.

As a result, Eskom’s load-shedding, tariff increases and power failures are not an issue. “I don’t know what Eskon is about,” Norman chuckles. And for him, electrical appliances are a cost saving rather than a luxury. “We put in an electric stove to save money! On a normal farm you wouldn’t do that,” he laughs.

A major benefit is that the turbines require minimal management and servicing. “It takes a couple of days in the year – just a bit of paint here and a bit of a clean-up there. We also have to check that the bearings and belts are in order and replace where necessary.” During a maintenance period, a standby 25kVA diesel generator supplies electricity to the farm.

Contact Norman Collett at nkacol@interkom.co.za.

Share
Published by
Caxton Magazines
Tags: cross-flow turbineselectricityEskomfarmgreat fish rivernorman corlettvortex hydro systemswater

Recent Posts

SA frozen chicken meat imports hit record levels last year

South Africa set a new record for the amount of frozen broiler meat that was brought into the country last…

16 hours ago

Mixed farming: key to livestock success for Free State farmer

Nelius Ferreira, the Free State’s Top Young Farmer for 2018, focuses on quality production in a global marketplace. Sabrina Dean…

17 hours ago

Wine industry satisfied with inflationary sin tax increase

The South African wine and brandy industry has welcomed the inflationary increase in excise duties announced by Finance Minister Tito…

2 days ago

Hedging market and climate risks on a family wine farm

Boplaas Family Vineyards shows that farm size does not really matter if you want to makeit in the wine industry.…

2 days ago

SA peanut plantings at lowest level ever

Only 19 200ha had been planted to peanuts in the 2018/2019 production season, which is the smallest area on record,…

2 days ago

No pay rise for MPs as govt seeks to close budget deficit

South Africa is not immune to events in the global economy and the expected slowdown in world economic growth will…

3 days ago

This website uses cookies.